Magnum Boots PORTABLE GENERATOR MPG 3800 Manuel d'utilisateur Page 1

PORTABLE GENERATORMPG 3800OPERATING/PARTS MANUAL

GROUND FAULT SENSING MODULEWARNINGTEST BEFORE EACH USESEE INSTRUCTIONSRESETRESETPOWERFAULTABCDEFG HMPG 380010CONTROL PANEL COMPONENTSA. ENGINE START S

GROUND SOURCELOCATION11GROUNDING THE GENERATORPREVENTION OF OVERLOADExceeding wattage capacity can result in damage to the generator and to the connec

12WATTAGE CONSUMPTION OF EQUIPMENTDEVICE APPROXIMATE RUNNING WATTSAir Conditioner (12,000 BTU)** ...

ADDING ENGINE OIL1. Place the pump on a firm, level surface.2. Remove the oil fill cap/dipstick. Clean the areaaround the oil fill cap and wipe the d

14STARTING THE ENGINE1. Unplug all electrical loads from the unit’s receptacles before starting the engine.2. Make sure the generator is on a firm, le

15STOPPING THE ENGINE2. Turn the idle control switch off.3. Switch the main circuit breaker to the off position.3. Let the unit run for 3-5 minutes wi

• Check the engine oil level daily before starting engine.• DO NOT start the generator if the oil level is low! The normal operating level for the en

GROUND FAULT SENSING MODULEWARNINGTEST BEFORE EACH USESEE INSTRUCTIONSRESETRESETPOWERFAULTGFCI TESTING INSTRUCTIONS TEST BEFORE EACH USE!Normal operat

TOFRAME1812151CONTROL PANEL ASSEMBLY324568791417911111016131918182020

19ITEM NO. PART NO. QTY DESCRIPTION1 26213 1 Panel, control - rear housing2 24986R 1 Panel, control3 65888 2 Receptacle, 120V/20A duplex-black4

2This manual provides information and procedures to safely operate and maintain the engine and genera-tor. For your own safety and protection from ph

20FRAME AND FUEL TANK ASSEMBLY118322145676822192928333291011133113301413101229281516172627192020232219272783435366252437

ITEM NO. PART NO. QTY DESCRIPTION1 26123 1 Valve, fuel tank2 26122 1 Gauge, fuel tank3 28495 1 Cap, fuel tank4 28494 1 Tank, fuel5 60393 4 S

TOMUFFLERTO FRAMETOFRAMETOFRAMEENGINE AND GENERATOR ASSEMBLY221132123451029127633381115161412171819824262518191924172320222117271918183029283132333435

ITEM NO. PART NO. QTY DESCRIPTION1 60028 8 Screw, .312-18X1.000 hx hd2 60271 10 Washer, split lock .3123 61147 8 Nut, .312-18 U-clip G5 ZY long t

24AC WIRING DIAGRAM1234(Y)(R)(B)(G)SEE DCPRINTWHT/BLKBLKCOMN/O1324LINELOADORN423COMMONS120 ONLY120/240XGWYGYWWXX867121011161415WXXGRN/YELWHTWHTWHTBLKY

DC WIRING DIAGRAM25ON/OFF SWITCHIDLE/RUN SWITCHIDLE/RUN MODULEGRNREDBLUORNIDLE/RUNSOLENOIDSHUTDOWNSOLENOIDCOILOIL LEVEL SWITCHOIL ALERT UNIT+ -CHARGE

26NOTES:

27

REV: APART NO: 2612601.18.08

TABLE OF CONTENTS3PageINTRODUCTION ...

Note: Notes contain additional information important to a procedure and will be found within the regulartext body of this manual.4OPERATING SAFETYBef

5ENGINE SAFETYInternal combustion engines present special hazards during operation and fueling! Failure to follow thesafety guidelines described belo

Unit ID Tag215 Power Drive • Berlin, WI 549231-800-926-9768MODELSERIAL NUMBERMPG 3800000000120/240 120/24031.7/15.828.3/14.2kglbs. amb. temp.rpm hz ph

Read and understand the supplied operator’s manual before operating unit.Hot surface(s) nearby.Fire/explosion hazard; Keep open flames away from unit.

27.0 in.36.8 in.21.4 in.22.0 in.21.5 in.8Read this manual carefully before attempting to use this generator. The potential for property damage, perso

FUEL TANK CAPFUEL LEVELGAUGEFUEL SHUTOFF VALVE(UNDER TANK)RECOILSTARTERCONTROL PANELENGINESTARTINGBATTERYBATTERY TRAY(OPTIONAL)ENGINEEXHAUSTWHEEL KIT(